This aftermarket kit comes with 12 volt headlights for each side along with the amber marker lights and black mounting bezels.
If your early DS golf cart never had recessed headlights a template is included so you will be able to cut the front cowl to fit these lights. You will need to order the light switch, wire, fuse and the floor mounted high/low beam switch separately if this light kit is an original installation. See our special quick links to these products below.
NOTE 1: This headlight set is made for DS Model Club Car Golf Carts made from 1982 to 1992. The aftermarket offers many different recessed light kits that appear similar to this light fixture. Just because a Club Car dealer installs a recessed light kit does not insure it is the OEM factory style or size. It can be hard to discern the subtle differences between the various makes especially if you are not looking at the fixture that needs replacing. If there are questions call us at 1-800-328-1953. It will be helpful to have a few pictures you can email us.
Bezel: 4" Tall x 7-3/8" Wide
Headlight: 2-7/8" Tall x 4" Wide
Amber Light: 2-3/4" Tall x 1" Wide
NOTE 3: If you need the factory replacement headlights set, please click on the following: Club Car 93-Up Headlight Replacement Set.
NOTE 4: You will need a On-Off Light Switch, if your vehicle does not already have one. Also, if you install any electrical accessory to your golf cart or utility vehilce, you should definitely install at least a In-Line Fuse. If you are installing several electrical devices, you will need a Fuse Block for multiple circuits, (20 amp fuses for the fuse block are best in this application).
NOTE 5: If you have a battery powered electric car and intend to use your lights a lot or add a tape or CD player, the drain on the two batteries used to supply all that needed power will cause them to fail prematurely. Those two batteries will get used a lot more than the others and they will not recharge as fully as they should. Over time they will become chronically undercharged killing them before their time and bringing down the performance of the car as they slowly die. To avoid this situation we suggest a DC to DC voltage reducer. A reducer is wired to all the batteries and it converts the total battery pack voltage down to a 12-volt supply to power the electrical accessories. It drains all the batteries evenly and allows them all to be recharged to the same level after each use. Any drain on a battery pack will shorten the life of the batteries but it is far batter to drain them equally than to drain one or two more so than the others. Please check out our Reducer page here.
This kit will not replace the factory recessed headlights featured on the DS Model Club Cars with the Armorflex cowl made from 1993 to present. These are smaller than the later factory headlight fixtures. The Armorflex cowls could be retrofitted to an older pre-93 DS model. This kit will not fit on the Club Car Precedent models either.